Product ID:CF OIL 1A, CF900
MSDS Date:09/03/1997
FSC:6850
NIIN:00N091376
Status Code:A
MSDS Number: CJJWG

Emergency Phone: 201-825-4000

Info Phone: 201-825-4000

Cage: 23736

Telephone: 201-825-4000

Cage: 23736

DIMETHYLPOLYSILOXANE

CAS: 63148-62-9

RTECS: JT6484500

LD50 LC50 Mixture:LD50:(ORAL,RAT) >5 G/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:SKIN CONTACT: MAY CAUSE SLIGHT SKIN
IRRITATION, BUT NO SIGNIFICANT EFFECTS. EYE CONTACT: MAY CAUSE
SLIGHT IRRITATION. INGESTION: ESTIMATED TO BE LOW-HARMFUL.
Explanation of Carcinogenicity:NO EVIDENCE OF CARCINOGENICITY IN
LABORATORY ANIMALS. IARC MONOGRAPHS: NOT LISTED. NTP (USA): NOT
LISTED. OSHA REGULATED (USA): NOT LISTED.
Effects of Overexposure:SEE HEALTH HAZARDS.

First Aid:INHALATION: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE
O*2/ARTF RESP) . SKIN: REMOVE PRODUCT FROM SKIN WITH DRY CLOTH OR
TOWEL, & WASH EXPOSED AREA WITH DETERGENT. EYES: IMMEDIATELY FLUSH
WITH WATER FOR AT LEAST 15 MINUTES. INGESTION: WASH OUT MOUTH WITH
WATER PROVIDED PERSON IS CONSCIOUS. NEVER GIVE ANYTHING BY MOUTH TO
AN UNCONSCIOUS PERSON. CALL MD IMMEDIATELY.

Flash Point Method:OC
Flash Point:=300.C, 572.F
Lower Limits:NOT AVAIL
Upper Limits:NOT AVAIL
Extinguishing Media:FOAM, DRY CHEMICAL OR CARBON DIOXIDE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NOT CONSIDERED FLAMMABLE NOR COMBUSTIBLE,
BUT WILL BURN IF INVOLVED IN A FIRE. HAZARDS CLASSIFICATION: NONE
(BASED ON IMO). FLAMMABILITY: NO DATA AVAILABLE. OXIDIZING
PROPERTIES: NO DATA AVAILABLE.

Spill Release Procedures:CONTAIN SPILL OR LEAK. SCRAPE UP WITH
CARDBOARD OR RAG & PLACE IN CONTAINER.

Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
STORE IN A COOL PLACE. KEEP AWAY FROM HEAT & FLAME. DO NOT LAY
CONTAINER ON ITS SIDE. AVOID CONTACT WITH EYES & PROLONGED OR
REPEATED SKIN CONTACT. KEEP OUT OF R EACH OF CHILDREN.
Other Precautions:EMPTIED CONTAINER: DO NOT RE-USE THIS CONTAINER. KEEP
AWAY FROM HEAT, SPARKS & FLAME. DO NOT PUNCTURE OR CUT THIS
CONTAINER & DO NOT WELD ON OR NEAR THIS CONTAINER.

Respiratory Protection:NONE REQUIRED WHEN USED AS INTENDED IN MINOLTA
EQUIPMENT. FOR USE OTHER THAN NORMAL-OPERATING PROCEDURES, NIOSH
APPROVED RESPIRATORS MAY BE REQUIRED.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:EYE WASH & DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA . NONE REQUIRED WHEN USED AS INTENDED IN MINOLTA
EQUIPMENT.
Work Hygienic Practices:WASH HANDS AFTER HANDLING.
Supplemental Safety and Health
PHYSICAL DATA: PARTITION COEFFICIENT, N-OCTANOL/WATER: NO DATA
AVAILABLE. -- TOX INFO: POTNTL CANCER HAZ. SO, USE ADEQ VENT/WEAR
PROT EQUIP SUCH AS GLOVES, GOGGS/PROT CLTHG WHEN THIS PROD IS
HEATED AT APPROX 150C(300F) & ABOVE IN THE PRESENCE OF AIR.

Vapor Pres:NEGLIGIBLE (25C)
Spec Gravity:0.970 (25C)
pH:NO DATA AVAIL
Viscosity:300 (CST)
Evaporation Rate & Reference:NEGLIG (BUTYL ACETATE=1)
Solubility in Water:NOT SOLUBLE (<1 PPM)
Appearance and Odor:COLORLESS, TRANSPARENT FLUID; ODORLESS.

Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:PREPARATION (COMMUNITY PROVISIONS): CAN BE
BURNED IN A CHEMIICAL INCINERATOR EQUIPPED WITH AN AFTERBURNER &
SCRUBBER. CONTAMINATED PACKAGING: DO NOT DISPOSE THE EMPTIED
CONTAINER UNLAWFULLY. OBSERVE A LL FEDERAL, STATE & LOCAL LAWS.

Toxicological Information:ACUTE TOX: LD50:(ORAL,RAT) >5 G/KG (ESTIMATED
BY SIMILAR DIMETHYLPOLYSILOXANE). LC50:(INHAL) G/M3/4H: N/A. EYE
IRRIT:MAY CAUSE TRANSITIONAL SLIGHT IRRIT. SKIN IRRIT:ESSNTLY NON
IRRIT. SKIN SENSITIZER: NO EVIID OF SENSIT. SUBACUTE TOX:NO EVID OF
SUBACUTE TOX IN RATS/MICE. MUTAGENICITY:NO EVID OF MUTAGENICITY.
CHRONIC TOX:NO SIGNIFICANT EFTS WERE OBSERVED. REPRO EFT:NO INFO IS
AVAIL. TERATOGENIC EFT: NO CLEAR EVID OF TERATOGENIC EFT
(ESTIMATED). OTHER INFO:THIS PROD CAN GENERATE FORMALDEHYDE AT
APPROX 150C(300F) & ABOVE IN PRESENCE OF AIR. FORMALDEHYDE IS SKIN
& RESP SENSITIZER, EYE & THROAT IRRIT , ACUTE TOXICANT, & (SUPP
DATA)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:BIODEGRADATION: NO EVIDENCE OF BIODEGRADATION.
BIOACCUMULATION: NO EVIDENCE OF BIOACCUMULATION. AQUATIC TOXICITY:
NO EVIDENCE OF AQUATIC TOXICITY. OTHER INFORMATION: MAY CAUSE
DECOMPOSITION IN DRY SOI LS.

Transport Information:UN NO: NONE. IMO CLASSIFICATION & CLASS: NONE.
PACKAGING GROUP: NONE. PROPER SHIPPING NAME: NONE. TECHNICAL
SHIPPING NAME: NONE. MARINE POLLUTANT: NONE. DOT REPORTABLE
QUANTITY (RQ): HAZARD SUBSTANCE( S) NAME/(CAS NO), CONTENTS & RQ:
NOT APPLICABLE.

SARA Title III Information:SARA (SUPERFUND AMENDMENTS & REAUTHORIZATION
ACT OF 1986) TITLE III 313 REPORTABLE INGREDIENTS: NONE.
Federal Regulatory Information:TSCA (TOXIC SUBSTANCES CONTROL ACT):
LISTED ON THE TSCA INVENTORY. EU INFORMATION: EINECS (EUROPEAN
INVENTORY OF EXISTING COMMERCIAL CHEMICAL SUBSTANCES): LISTED ON
THE EINECS. INFORMATION ON THE LABE LING-REGULATIONS: SYMBOL: NOT
REQUIRED. R-PHRASE: NOT REQUIRED. S-PHRASE: NOT REQUIRED. CONTAINS:
NONE.
State Regulatory Information:CALIFORNIA PROPOSITION 65: THIE PRODUCT
CONTAINS NO CHEMICAL SUBSTANCES SUBJECT TO CALIFORNIA PROPOSITION
65.